三向格栅与细粒尾矿界面特性拉拔试验研究

doi:10.16265/j.cnki.issn 1003-3033.2021.01.010

中国安全科学学报 ›› 2021, Vol. 31 ›› Issue (1): 67-74.doi: 10.16265/j.cnki.issn 1003-3033.2021.01.010

三向格栅与细粒尾矿界面特性拉拔试验研究

易富¹ 教授, 于犇², 于汇泽³ 高级工程师, 杜常博², 金洪松²

1 辽宁工程技术大学建筑与交通学院,辽宁阜新,123000;
2 辽宁工程技术大学土木工程学院,辽宁阜新,123000;
3 长春高新建设开发有限公司,吉林长春,130000

收稿日期:2020-10-15 修回日期:2020-12-12 出版日期:2021-01-28 发布日期:2021-07-28
作者简介:易富 (1978—),男,河北张北人,博士,教授,主要从事环境岩土工程及道路工程方面的研究。E-mail:yifu9716@163.com。
基金资助:
国家自然科学基金资助(51774163)。

Pull-out test study on interface characteristics of traixial geogrid and fine tailings

YI Fu¹, YU Ben², YU Huize³, DU Changbo², JIN Hongsong²

1 College of Architecure and Transportation, Liaoning Technical University, Fuxin Liaoning 123000, China;
2 School of Civil Engineering, Liaoning Technical University, Fuxin Liaoning 123000, China;
3 Changchun High New Technology Building Development Inc, Changchun Jilin 130000, China

Received:2020-10-15 Revised:2020-12-12 Online:2021-01-28 Published:2021-07-28

摘要/Abstract

摘要： 为提高细粒尾矿坝的安全稳定性,提出三向格栅加筋增强细粒尾矿力学性质的方法,以细粒尾矿为填料,开展不同工况下的双向、三向格栅拉拔试验,分析2种格栅的加筋效果差异,着重研究相对密实度、含水率及法向应力对三向格栅-细粒尾矿界面特性的影响。研究结果表明:三向格栅加筋效果优于双向格栅,界面强度参数上表现为似摩擦角的差异,且法向应力越高越有利于提高三向格栅加筋效果;相对密实度的增大对界面摩擦强度提高明显,界面似黏聚力和综合摩擦因数比随相对密实度单调递增,而似摩擦角增幅很小;天然含水率下界面摩擦强度大于饱和含水率界面,前者界面似黏聚力是后者的1.28倍,而似摩擦角近似相等。

关键词: 三向格栅, 细粒尾矿, 界面特性, 拉拔试验, 相对密实度, 含水率

Abstract: In order to improve safety and stability of fine tailings dam, a method of strengthening its mechanical properties by traixial geogrid reinforcement was put forward, and pull-out tests of biaxial and traixial geogrid under different conditions were carried out with fine tailings as fillers. Then, difference in reinforcement effects of these two geogrids were analyzed, and influence of relative density, water content and normal stress on interface characteristics of traixial geogrid were emphatically studied. The results show that traixial geogrid has better reinforcement effect than biaxial one, and interface strength parameters show difference of pseudo-friction angle. Moreover, the higher normal stress is, the better reinforcement effect of traixial geogrid will be. It is also found that increase of relative density significantly improves interfacial friction strength, and pseudo-cohesion and friction coefficient ratio monotonically increase along with relative density while apparent friction angle changes little. Interfacial friction strength at natural water content is greater than that at saturated water content. The former has 1.28 times of the latter's pseudo-cohesion, while pseudo-friction angle are approximately equal.

Key words: traixial geogrid, fine tailings, interface characteristics, pull-out tests, relative density, water content

中图分类号:

X936

易富, 于犇, 于汇泽, 杜常博, 金洪松. 三向格栅与细粒尾矿界面特性拉拔试验研究[J]. 中国安全科学学报, 2021, 31(1): 67-74.

YI Fu, YU Ben, YU Huize, DU Changbo, JIN Hongsong. Pull-out test study on interface characteristics of traixial geogrid and fine tailings[J]. China Safety Science Journal, 2021, 31(1): 67-74.

参考文献

[1] 李辉,易富,张佳.基于因素空间的尾矿坝稳定性综合评价[J].中国安全科学学报,2019,29(12): 28-34.
LI Hui,YI Fu,ZHANG Jia.Comprehensive stability evaluation of tailing dam based on factor space[J]. China Safety Science Journal,2019,29(12): 28-34.
[2] 张媛媛,杨凯.尾矿库生命周期溃坝风险演化研究[J].中国安全科学学报,2017,27(7): 1-6.
ZHANG Yuanyuan,YANG Kai.Research on evolution of risk of tailings dam-break in lifecycle[J]. China Safety Science Journal, 2017,27(7): 1-6.
[3] 陈守义.浅议上游法细粒尾矿堆坝问题[J].岩土力学,1995,16(3): 70-76.
CHEN Shouyi.Discussion on the problem of fine graiend tailings dam by upstream method[J].Rock and Soil Mechanics,1995,16(3): 70-76.
[4] 杜艳强,王新武,张坤,等.细粒尾矿坝漫顶溃坝机制及灾变过程[J].中国安全科学学报,2017,27(2): 104-108.
DU Yanqiang,WANG Xinwu,ZHANG Kun,et al.Process and mechanism offine grained tailings dam's failure due to overtopping[J]. China Safety Science Journal,2017,27(2): 104-108.
[5] ZHANG Hongzhu,WANG Laigui,FENG Meisheng.Stability study of the geogrids reinforced tailings[J].Advanced Materials Research,2011,1443(327): 1-5.
[6] 魏发正.金马铅锌矿细粒尾矿库的加固实践[J].矿业安全与环保,2008,35(4): 47-51.
WEI Fazheng.Reinforcement practice of Jinma lead-zinc mine fine graiend stailings pond[J].Mining Safety & Environmental,2008,35(4): 47-51.
[7] 杨广庆,李广信,张保俭.土工格栅界面摩擦特性试验研究[J].岩土工程学报,2006,28(8): 948-952.
YANG Guangqing, LI Guangxin, ZHANG Baojian.Experimental studies on interface friction characteristics of geogrids[J]. Chinese Journal of Geotechnical Engineering, 2006, 28(8): 948-952.
[8] 汪明元,包承纲,丁金华,等.试验条件对土工格栅与膨胀土界面拉拔性状的影响[J].岩土力学,2008,29(11): 442-448.
WANG Mingyuan, BAO Chenggang, DING Jinhua,et al.Effect of some test conditions on pull-out behaviors of interfacebetween geogrids and compacted expansive soils[J].Rock and Soil Mechanics,2008,29(11): 442-448.
[9] 尹光志,张东明,魏作安,等.土工合成材料与细粒尾矿界面作用特性的试验研究[J].岩石力学与工程学报,2004,23(3): 426-429.
YIN Guangzhi,ZHANG Dongming,WEI Zuoan,et al.Testing study on interaction characteristic between fine graiend tailings and geosynthetics [J].Chinese Journal of Rock Mechanics and Engineering,2004,23(3): 426-429.
[10] 杜坤乾,李国祥,李品华,等.钢塑土工格栅在土石混合料中的拉拔试验研究[J].防灾减灾工程学报,2015,35(5): 644-650.
DU Kunqian,LI Guoxiang,LI Pinhua,et al.Experimental study on drawing plastic geogrid in soilrock mixture[J].Journal of Disaster Prevention and Mitigation Engineering,2015,35(5): 644-650.
[11] 王家全,陆梦梁,周岳富,等.土工格栅纵横肋的筋土承载特性分析[J].岩土工程学报,2018,40(1): 186-193.
WANG Jiaquan,LU Mengliang,ZHOU Yuefu,et al.Bearing characteristics of reinforced soil with longitudinal and transverse ribs of geogrids[J]. Chinese Journal of Geotechnical Engineering,2018,40(1): 186-193.
[12] 陈榕,王喜强,郝冬雪,等.季节性冻土中土工格栅加筋特性试验研究[J].岩土工程学报,2019,41(6): 1 101-1 107.
CHEN Rong,WANG Xiqiang,HAO Dongxue,et al.Experimental investigation on reinforced characteristics of geogrids in seasonal frozen soil[J].Chinese Journal of Geotechnical Engineering,2019,41(6): 1 101-1 107.
[13] ZHOU J,CHEN J F, XUE J F, et al.Micro-mechanism of the interaction between sand and geogrid transverse ribs[J].Geosynthetics International,2012,19(6): 426-437.
[14] KHEDKAR M S, MANDAL J N. Pullout behavior of cellular reinforcements[J].Geotextiles and Geomembranes,2009, 27(4): 262-271.
[15] 苗晨曦,郑俊杰,崔明娟,等.三向土工格栅筋土界面及摩擦特性的离散元模拟[J].岩土力学,2014,35(增1): 423-430.
MIAO Chenxi, ZHENG Junjie, CUI Mingjuan,et al.Discrete element simulation of interface characteristic and frictional properties of triaxial geogrid[J].Rock and Soil Mechanics,2014,35(S1): 423-430.
[16] 周小凤,张孟喜,邱成春,等.不同形式土工格栅加筋砂的强度特性[J].上海交通大学学报,2013,47(9): 1 377-1 381.
ZHOU Xiaofeng,ZHANG Mengxi,QIU Chengchun,et al.Strength of sand reinforced with different forms of geogrid [J].Journal of Shanghai Jiaotong University,2013,47(9): 1 377-1 381.
[17] 郑俊杰,曹文昭,周燕君,等.三向土工格栅筋-土界面特性拉拔试验研究[J].岩土力学,2017,38(2): 317-324.
ZHENG Junjie,CAO Wenzhao,ZHOU Yanjun,et al.Pull-out test study of interface behavior between triaxial geogrid and soil[J].Rock and Soil Mechanics,2017,38(2): 317-324.
[18] 蔡清,程江涛,于沉香.细粒尾矿的定义及分类方法探讨[J].土工基础,2014,28(1): 91-93.
CAI Qing,CHENG Jiangtao,YU Chenxiang.Definition and classification of fine grain masterials from mine tailings[J]. Soil Engineering and Foundation,2014,28(1): 91-93.
[19] SL 235—2012, 土工合成材料测试规程[S].
SL 235-2012, Specification for test and measurement of geosynthetics[S].
[20] 包承纲.土工合成材料界面特性的研究及试验验证[J].岩石力学与工程学报,2006,25(9): 1 735-1 744.
BAO Chenggang. Study on interface behavior of geosynthetics and soil[J].Chinese Journal of Rock Mechanics and Engineering, 2006, 25(9): 1 735-1 744.
[21] 唐晓松,郑颖人,王永甫,等.关于土工格栅合理网孔尺寸的研究[J].岩土力学,2017,38(6): 1 583-1 588.
TANG Xiaosong,ZHENG Yingren,WANG Yongfu,et al.Study on the reasonable size of geo-grid meshes[J].Rock and Soil Mechanics,2017,38(6): 1 583-1 588.
[22] 丁鲁强,李大勇,陈福全.土工格栅与饱和细砂的界面特性试验研究[J].长江科学院院报,2018,35(11): 101-106.
DING Luqiang,LI Dayong,CHEN Fuquan.Experimental study on the properties of interface between geogrid and saturated fine sand[J].Journal of Yangtze River Scientific Research Institute,2018,35(11): 101-106.
[23] 史旦达,刘文白,水伟厚,等.单、双向塑料土工格栅与不同填料界面作用特性对比试验研究[J].岩土力学,2009,30(8): 2 237-2 244.
SHI Danda,LIU Wenbai,SHUI Weihou,et al.Comparative experimental studies of interface characteristics between uniaxial/biaxial plastic geogrids and different soils[J]. Rock and Soil Mechanics,2009,30(8): 2 237-2 244.

三向格栅与细粒尾矿界面特性拉拔试验研究

Pull-out test study on interface characteristics of traixial geogrid and fine tailings

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 10

编辑推荐

Metrics

本文评价

[1]	任永婕, 魏建平, 温志辉, 张俊昭, 姚帅. 煤岩自振频率的影响因素试验研究^*[J]. 中国安全科学学报, 2021, 31(8): 104-111.
[2]	刘艳, 刘永, 徐正华, 洪昌寿, 章求才, 袁劲帆. 长期高温下铀尾矿库覆土层控氡性能研究[J]. 中国安全科学学报, 2020, 30(3): 171-177.
[3]	郑彬彬, 张东明, 王浩, 杨瀚. 玄武岩纤维增强尾矿力学性能的试验研究[J]. 中国安全科学学报, 2019, 29(3): 114-119.
[4]	翟胜男, 陈太球, 蒋春燕, 傅佳佳, 王鸿博. 含水率对防护织物热防护性能的影响[J]. 中国安全科学学报, 2018, 28(7): 148-152.
[5]	周西华, 童谣, 宋东平, 白刚, 李昂. 基于响应曲面法的松散煤体导热系数测试与分析[J]. 中国安全科学学报, 2018, 28(10): 105-110.
[6]	康向涛, 刘勇, 江成玉, 宋真龙, 高林. 含水率对预制裂纹煤样能耗与破坏模式的影响[J]. 中国安全科学学报, 2017, 27(7): 94-98.
[7]	林雪松, 陈殿强, 王来贵. 非饱和尾矿砂抗剪强度参数分布与安全影响[J]. 中国安全科学学报, 2017, 27(4): 116-121.
[8]	岳基伟, 王兆丰教授, 陈金生讲师, 李皓伟. 用水敏指示剂快速测定重塑煤体渗吸高度的研究[J]. 中国安全科学学报, 2017, 27(11): 126-131.
[9]	李孜军，徐志国，邓艳星. 氧化增重法测试硫化矿石低温氧化性参数优化[J]. 中国安全科学学报, 2012, 22(6): 54-.
[10]	路长，余明高，林棉金，陈亮，贾海林. 水分影响下阴燃传播及气相反应发生的研究[J]. 中国安全科学学报, 2008, 18(5): 91-.